Jurnal Reaksi (Journal of Science and Technology) Jurusan Teknik Kimia Politeknik Negeri Lhokseumawe Vol. 19 No.02, Desember 2021 ISSN 1693-248X 1 OPTIMALISASI GLYCOL DEHYDRATION UNIT SPESIFIKASI Gas Moisture Content LAPANGAN GAS LEPAS PANTAI KEPODANG BLOK MERIAH Saiful Bahri 1 dan Abas Sato 1 1 Chemical Engineering Department, Universitas WR Supratman, Surabaya *E-mail penulis: Saiful_nh3@yahoo.co.id, abassato2@gmail.com, ABSTRAK Pada umumnya gas alam (natural gas) yang baru keluar dari perut bumi memiliki kandungan uap air yang cukup tinggi dalam kondisi saturated (jenuh). Kandungan air yang tinggi akan menyebabkan kemungkinan timbulnya hidrat semakin besar sehingga gas tersebut menimbulkan permasalahan dalam operasional pabrik dan dapat menurunkan nilai jual secara ekonomis. Kandungan air harus dihilangkan sampai potensi pembentukan hidrat didalam gas serendah mungkin. Penurunan kandungan air dalam gas ini akan meningkatkan nilai kalori gas tersebut, juga memudahkan dalam pengoperasian gas dan mencegah kerusakan peralatan operasional (Saka Energi Muriah Limited, 2020). Gas dehydration unit dan TEG Regeneration unit memiliki desain awal dengan gas umpan maksimum sebesar 145 MMSCFD, akan tetapi saat ini rate gas maksimum hanya 20 MMSCFD saja. Penelitian ini mengkaji optimalisasi Glycol Dehydration Unit yang efektif pada desain dengan kapasitas yang besar tetapi bisa di andalkan dan beroperasi baik pada kondisi rate gas jauh di bawah desainnya hingga ke batas minimumnya. Optimalisasi dilakukan sampai menemukan kesetimbangan baru di unit Glycol Dehydration dan dapat meningkatkan nilai kalori nantinya. Kata kunci: glycol dehydration, gas processing, proses pemurnian gas, blok muriah, lapangan Kepodang ABSTRACT In general, natural gas that has just come out of the bowels of the earth has a fairly high-water vapor content in a saturated condition. The high-water content will cause the possibility of hydrate to be greater so that the gas causes problems in plant operations and can reduce the selling value economically. The water content should be removed until the potential for hydrate formation in the gas is as low as possible. The decrease in the water content in this gas will increase the calorific value of the gas, also facilitate the operation of the gas and prevent damage to operational equipment (Saka Energi Muriah Limited, 2020). The gas dehydration unit and TEG Regeneration unit were originally designed with a maximum feed gas of 145 MMSCFD, but currently the maximum gas rate is only 20 MMSCFD. This study examines the optimization of the Glycol Dehydration Unit which is effective in a design with a large capacity but can be relied upon and operates well at gas rate conditions far below its design to the minimum limit. Optimization is carried out until a new equilibrium is found in the Glycol Dehydration unit and can increase the calorific value later. Key words: glycol dehydration, gas processing, proses pemurnian gas, blok muriah, lapangan Kepodang