1 Copyright © 2011 by ASME Proceedings of ASME Turbo Expo 2011 GT2011 June 6-10, 2011, Vancouver, Canada GT2011-45609 DEVELOPMENT AND TESTING OF SUSTAINABLE REFRIGERATION PLANTS Luciano A. Catalano Polytechnic University of Bari Dept. of Mechanical and Management Engineering Via G. Re David, 70125, Bari, Italy Fabio De Bellis Polytechnic University of Bari Dept. of Mechanical and Management Engineering Via G. Re David, 70125, Bari, Italy Riccardo Amirante Polytechnic University of Bari Dept. of Mechanical and Management Engineering Via G. Re David, 70125, Bari, Italy ABSTRACT Although Ozone Depleting Substances (ODS) were banned with the Montreal Protocol in 1987, current refrigeration plants can not be considered sustainable for the environment. ODS have been in fact substituted by gases with high Global Warming Potential (GWP). Among many alternatives, inverse Joule Brayton air cycle had been already implemented and tested for refrigeration purposes. In the open cycles described in the available literature, the operating fluid (air) is firstly compressed by a bootstrap (volumetric) compressor and then processed by a second (centrifugal) compressor and cooled; then, it is expanded in a turbine which drives the centrifugal compressor and discharges a cold flow which can be used (directly or indirectly) for refrigeration purposes. In this work, an inverse Joule Brayton air cycle has been studied with the employment of turbocharger units. Experimental tests have been performed in order to reproduce the state-of-the-art with a small automotive turbocharger unit. Measurements show Coefficient Of Performance (COP) smaller than unit together with minimum turbine exit temperature equal to -10°C. This is due to low components efficiency: the analysis of turbine and turbocompressor maps highlights a non-optimal coupling between them. Secondly, basing on these considerations, two new air cycle layouts are proposed and analyzed. Calculations performed by means of a thermodynamic model show that higher COP and lower cycle minimum temperature can be achieved with the proposed new cycles by means of better turbine and turbocompressor matching and bigger turbocharger units with higher components efficiency. INTRODUCTION Refrigeration plants are crucial components in our daily life, since they are used for food preservation, air conditioning and many industrial applications like, for example, medical and pharmaceutical ones. Apart from cryogenic applications, almost the totality of refrigeration plants are based on vapour compression cycles. Historically, these cycles used refrigerants that were found to be Ozone Depleting Substances (ODS) and were banned in 1987 with the Montreal Protocol. However, ODS gases like clorofluorocarbons (CFC) and hydroclorofluorocarbons (HCFC) have been substituted by global warming potential (GWP) gases as hydrofluorocarbons (HFC) and perfluorocarbons (PFC). Fig. 1 – Global Warming Potential (GWP) of the most common refrigerants, according to IPCC [1]. Figure 1 shows the GWP of the most used gases in refrigeration plants; such gases are constantly released in the atmosphere through plant leakages. Additionally, the Environmental Protection Agency (EPA) of the United States estimates that