Silicon nanoparticles: a new and enhanced operational material for nitrophenol sensing Rizwan Wahab 1, * , Naushad Ahmad 2 , and Manawwer Alam 2 1 Department of Zoology, College of Science, King Saud University, P.O. Box 2455, Riyadh 11451, Saudi Arabia 2 Department of Chemistry, College of Science, King Saud University, P.O. Box 2455, Riyadh 11451, Saudi Arabia Received: 7 May 2020 Accepted: 17 August 2020 © Springer Science+Business Media, LLC, part of Springer Nature 2020 ABSTRACT The environmental problem is a big issue in the current scenario because the human beings are affected via natural or manmade sources. Over a range of industrial pollutents, the nitrophenol (referred to as 4-NP) known as harmful industrial chemical for the environment and listed as a carcinogenic compound for human health. To keep this view the present manuscript describes the for- mation of highly crystalline silicon nanoparticles (Si-NPs) and applied for the electrochemical sensing of 4-NP. The Si-NPs exhibit numerous applications in various directions such as catalyst, solar cells, LEDs, batteries etc. The Si-NPs were formed from the physical approach with using argon-silane mixture in a gas chamber with impregnation of microwave plasma. The processed material was examined through various techniques such as X-ray diffraction pattern (XRD), field emission scanning electron microscopy (FESEM), transmission electron microscopy (TEM) and Fourier transform spectroscopy (FTIR). It reveals from the acquired analysis that the size of each NP is *4 nm with good structural and chemical characteristics and applied as a film form against to check the sensing of 4-NP with three electrode system. The electrochemical studies were conducted through cyclic voltammetry (CV) in terms of their low to high concentration (7.8, 15.62, 31. 25, 62.25, 250, 500, 1000 μM in PBS), scan rate at variable potential was accessed from 5 to 100 mV with Si-NPs based electrode. The sustainability, reproducibility and efficacy of the formed sensor (Si-NPs/GCE) was examined in occurrence with 4-NP (62.25 μM) for seven consecutive cycles. Including to this, chronoamperometry (0 to 1500 s) and electrochemical impedance spectra (7.8–1000 μM in PBS) were also analyzed. On the basis of acquired results and discussion a probable mechanism was also described. Address correspondence to E-mail: rwahab05@gmail.com; rwahab@ksu.edu.sa https://doi.org/10.1007/s10854-020-04269-8 J Mater Sci: Mater Electron