IOSR Journal of Environmental Science, Toxicology and Food Technology (IOSR-JESTFT) e-ISSN: 2319-2402,p- ISSN: 2319-2399.Volume 11, Issue 5 Ver. IV (May. 2017), PP 38-48 www.iosrjournals.org DOI: 10.9790/2402-1105043848 www.iosrjournals.org 38 | Page The Use of Cereal Components in the Preparation of Ice Milk Fatma Salama, Mohamed Azzam and Mohamed Saad Dairy Sci. Dept., Fac. Agric., Cairo Univ., Giza, Egypt Abstract: The purpose of this study was to investigate preparation of ice milk mixes by substituting oat milk and oatmeal or barley milk and milled barley instead of buffalo skim milk (BSM) and skim milk powder (SMP) at ratios 0 : 100 (C 0 ), 25 : 75 (OC 25 & BC 25 ), 50 : 50 (OC 50 & BC 50 ), 75 : 25 (OC 75 & BC 75 ) and 100 : 0 (O 100 & B 100 ) and substituting their blend instead of BSM and SMP at ratio 75 : 25 (OBC 75 ) and evaluation of frozen products physically, sensually, economically and nutritionally. The ice milk made from 100% BSM and SMP served as the control (C 0 ). The results showed that replacement of non fat milk solids (MSNF) with grain oat and barley components increased pH and viscosity values and decreased the specific gravity (Sp.gr), weight per gallon (Wt/gal) and whipping ability of ice milk mixes. Ice milk mixes made from 100% grain oat and barley components were excluded from the ice milk processing because of their very high viscosity and very low whipping ability. Incorporation of oat's or barley's components into ice milk mixes negatively affected Sp.gr, Wt/gal, overrun values and meltdown rate of the resultant ice milks. Results of sensory evaluation showed that most acceptable ice milks compared to untreated ice milk (C 0 ) they order BC 25 -, OC 25 -, BC 50 -, OBC 75 - and OC 50 - ice milk. Economically, BC 25 - ice milk was the least expensive, followed by BC 50 - and OC 25 - then OBC 75 - ice milk. The nutritional analysis of ice milks more palatable sensually and economically (BC 25 -, BC 50 -, OC 25 - and OBC 75 - ice milk) indicated that calories, protein, ash, carbohydrate and dietary fibers were found to be good amount in comparison to C 0 . Thus, these ice milks would be highly nutritious and not expensive. Key words: cereal, oat, barley, ice milk, replacement, nutritional analysis. I. Introduction Nowadays dairy factories are a trend towards increased production of dairy products low in their fat content and rich in nutraceutical and functional properties. Consumers are interested in eating these products that must be acceptable 'taste and appearance' and cheap. Among of these products, many kinds of new regular and low fat ice cream or known as ice milk available in the markets now. Substitution of functional food ingredients with health benefits instead of traditional ingredients in ice cream formulations without altering taste, mouthfeel, or other sensory properties was goal of various studies reported in the literature (Bisla et al., 2012, Karaman and Kayacier 2012, Wangcharoen 2012, Sun-waterhous et al., 2013, Ahanian et al., 2014 and Umelo et al., 2014). Oat (Avena sativa) and barley (Hordeum volgare L.) are under-utilized grains in human nutrition, yet they are good sources of dietary fiber, especially β-glucan, essential amino-acids, unsaturated fatty acids, vitamins, minerals and antioxidants (Huttner and Arendt 2010). Grain oat and barley products are several such as oat milk and barley milk. Whether is similar to cow milk in its gross chemical composition addition to their iron, zinc and dietary fiber contents (Hurrell et al., 2000). Also, they are similar to cow milk in its fluidity but they have the higher viscosity and starchy taste (Ali 2012). Oat's and barley's milk are cheaper than cow's milk as protein sources with high nutritional value. Consequently, they can be used as a suitable healthy alternative for cow's milk in manufacture of like dairy products ( Newman and Newman 2006, Queenan et al., 2007, Walsh et al., 2010 and Ali 2012). The purpose of this study was to substituting oat milk and oatmeal or barley milk and milled barley or their blend instead of buffalo skim milk and skim milk powder in manufacture of like ice milk and evaluation of frozen products physically, sensually, economically and nutritionally. II. Materials And Methods 2.1. Ingredients Fresh raw buffalo's milk was obtained from the herd of the Faculty of Agriculture Cairo University, Egypt and fresh skim milk (9.53% TS, 0.1% Fat, 3.7% Protein, 0.73% Ash, 5% Lactose, Sp.gr 1.0391) and cream (48.48% TS, 45% Fat, 1.53% Protein, 0.12% Ash, 1.83% Lactose) were obtained by separating of fresh buffalo's milk using cream separator (made in Egypt). Oat's (Avena sativa) and hull less barley's (Hordeum vulgare - Giza 129) grain were obtained from Agriculture Research Center, Giza, Egypt. Oat milk (9.49% TS, 0.018% Fat, 1.16% Protein, 0.36% Ash, 7.95% Carbohydrates, Sp.gr 1.019) and barley milk (9.4% TS & 0.01% Fat, 1.15% Protein, 0.54% Ash, 7.85% Carbohydrates, Sp.gr 1.022) were prepared according to steps were described by Ali (2012). White oat flakes (91% TS, 8.4% Fat) made in UK was purchased from the local market. Oat flakes and barley grains were milled (using standard electric grinder, Moulinex ® , France) and sieved by stainless steel sieves (60 mesh) to obtainment oat's and barley's powder (91%TS, 7% Fat, 12.1% Protein, 2.6% Ash, 69.3% Carbohydrates and 92%TS, 1.22% Fat, 8.9% Protein, 2.56% Ash, 79.32%